CQI 第二版 中英文

admin管理员组

文章数量:1531705

2024年1月18日发(作者：)

PROCESS TABLE J - Process Control and Testing Equipment过程表J-过程控制和测试设备All requirements given below are subordinate to applicable customer/OEM specific customer may have additional requirements, e.g., inspection testing, greater frequencies, etc. When performing the job audit, the auditor shall verify plater is conforming to customer requirements.*If minimum requirements are not met, provide supporting records to justify actual conditions. To justify reduced monitoring frequencies, a minimum of 30 consecutive measurements (data points) at statedfrequencies must be documented. If any data points at reduced monitoring frequencies are outside of control limits, then revert back to the frequencies stated under the minimum multiple tanks that serve the same purpose copy and paste sections as needed.下列所有要求都必须遵从客户/主机厂的具体要求。客户可能有附加的要求，如：检查测试、更大的频率等。作业审核时，审核员必须检查电镀厂是否符合客户要求。*如果无法满足最低要求，需要提供支持记录来证明实际条件。为证明降低的监测频率，至少要对规定频率采取30个连续测量(数据点）并记录在案。如果降低监测频率的数据点不在控制范围内，则必须回到最低要求的规定频率。对于目的相同的多个槽，复制粘贴需要的部分。Calibration /CertificationFrequency校准/认证频率Observation/Comments(Pass / Fail / N/A)观察/评论(通过/不通过/不适用)ITEM #项目1.0J1.1EQUIPMENT TYPE设备类型Zinc/ZincAlloy锌/锌合金DecorativeElectrolessHardChromeElectropolishPlatingNickelChromeflash电解抛光装饰电镀化学镀镍镀硬铬铬着色LABORATORY EQUIPMENT实验室设备VerificationFrequency检查频率J1.2Wet Analysis:Before use, chemicals must be checked for shelf life and/orexpiration date湿法分析： 使用前，必须检查化学品保存期限和/或截止日期pH / Conductivity Meter PH计/电导体pH / Conductivity ProbesSolution compatible probes must be ted probes must be used for chromates / 计/电导控头 溶液通过通用控头。铬酸盐或钝化采用专用控头Laboratory Balance (Weight Scale) (Optional)实验室天平(重量范围内)(可选)Atomic Absorption (AA)* 原子吸收分光光度计X-Ray Fluorescence (XRF) X射线荧光测厚仪Hardness Tester* 硬度仪Profilometer 粗糙度仪Lab Rectifier 实验室整流器TESTING EQUIPMENT测试设备Salt Spray Cabinet 盐雾试验箱Thickness Tester 厚度测试仪Coulometric (STEP) Tester 库伦(step)测厚仪CASS Cabinet CASS 箱Microscope (Min 100X)with calibrated grid reticle for Pore/Crack Count用于微孔/裂缝数量的校准网络十字线显微镜(最小0.1X)Freezer 冷冻箱Lab Oven 实验室烘箱PROCESSING EQUIPMENT过程设备J1.3J1.4J1.5J1.6J1.7J1.8J1.92.0J2.1J2.2J2.3J2.4J2.5J2.6J2.73.0

Rectifier 整流器J3.1Amp Meter/Volt Meter安培表/伏特表J3.2J3.3J3.4J3.5J3.6J3.7Plating Solution Filters 电镀溶液过滤机Plate filters (bright and semi-bright nickel tanks) 电镀过滤机(光亮与半光亮镍槽)Oven Temperature recorder烘箱温度记录仪Data/Chart recorder for deembrittlement or EN hardness oven去氢或化学镀镍硬度烘箱用数据/图表记录仪Thermocouples热电偶Controllers:(If Used)控制器(如果用)J3.8J3.9Automatic feeders自动加料机J3.10Timers 计时器J3.11Temperature 温度J3.12Volume 体积J3.13pH / Conductivity PH/电导仪J3.14Agitation type:搅拌类型J3.15Air 空气J3.16Cathode rod 阴极移动J3.17Eductor 喷射J3.18Water source:水源J3.19POTW自来水J3.20RO反渗透水J3.21Well地下水J3.22Deionized去离子水J3.23Drying type:烘干类型J3.24Spin Dryer旋转式脱水机J3.25Forced Air Drying风干J3.26Belt Oven网带式炉J3.27Box Oven箱式炉

本文标签： 要求频率检查数据控头